If the rings were not seated correctly wouldn't it be blowing oil out the tail pipe? No smoke at all from the tail pipe. I used a 1.2mm HKS MHG, could the clearance be too tight causing too much pressure?
Drove it per the break in procedure recommended on the forum. No boost for 500 miles. Started to crank up the boost to 8 PSI and now have a huge oil leak going into the intercooler. No smoke from the tail pipe, Turbo has been rebuilt and rechecked, PCV system checked and re-checked. Only ran for...
Guys,
We are stumped. Just installed a new rebuilt short block and rebuilt head with MHG, ARPs, new oil pump, etc. It runs fine and sounds good but will not boost and blows oil from the valve cover PCV into the intercooler. It also has a new Turbo we have checked twice and we have checked the...
We must be talking about a different part. The part I am looking at is the check valve behind the idle control valve that mounts to the intake. Not sure if this could cause the issue or not?
Where is the TB valve located you are talking about and can it be cleaned?:1zhelp:
It looks like the TB orifice might be clogged, how do I check it? Do you know where I can find the part number or is it listed in the TSRM? I'm looking but do not see it?
Most of the oil is in the intercooler piping and intercooler. I just pulled the check valve and there is some small amount of oil behind it in the intake manifold. Looks like it could be bad? The engine is new, less than 2K miles on it so I do not think the engine has a problem.
The drain line is good, new and checked it twice, it is routed to the original factory return on the block. This is a JT57 Turbo with the boss housing and braided lines. I have not checked the TB orifice, everything else appears to be good. I will double check it. Man, that would be too easy but...
New Turbo, even tried another one, and it still sucks oil into the intercooler? It sucks a quart about evry 20 miles. Solid engine, no boost leaks, etc. I am at a loss????? Help!:aigo:
Here is the link for my build and the latest shots. Now on my 2nd MHG after the TX2K7. She is running like a bat out of Hell now, too many past issues to discuss here. Back in Black!!!! :naughty: :naughty: :naughty:
http://www.cardomain.com/ride/827858
Thanks for Looking,
Luigi
This site uses cookies to help personalise content, tailor your experience and to keep you logged in if you register.
By continuing to use this site, you are consenting to our use of cookies.